新闻详情

介绍关于气动试压泵用途

今天我们济南气体增压泵

Today we Ji'nan gas booster pump manufacturers Xiaobian to introduce the use of pneumatic pressure test pump:

用于石油化工工程的防喷器、阀门、管道、锅炉等一切承压容器进行液体试压检测。(泵可作防 喷器控制系统中压力源)。

Used in petrochemical engineering, BOP valves, pipes, boilers and other pressure vessels were all liquid pressure test. (pump for BOP control system in pressure source).

1、气源接入口与进气胶管接头连接,被试件的容积越小,升压的速度越要快。

air access and inlet hose connector, the specimen volume is smaller, faster and faster boost.

2、进行试压工作时操作人员必须注意压力表的升压情况及联接处的渗漏情况发现问题应立即停泵、卸压排除。

the pressure test work operation personnel must pay attention to gauge pressure boost and junction leakage found the problem should immediately stop the pump, pressure relief excluded.

3、高压泵只是起增压作用启动该泵并不增加排量因而在向被检容器灌液时应使该泵停止动作免使液缸密封件无功损。

the high-pressure pump is supercharging start the pump does not increase the displacement thus to be seized vessel liquid filling should make the pump stop action free to make hydraulic cylinder seal reactive power loss in the.

4、在使用清水作液压介质时试压完毕后或下班前应堵住试压接出口按操作规程第4、5条所示操作。启动气动泵运转一分用水箱内乳化油或液压油循环以冲洗清水免使清水在机内停留过久而产生锈蚀。

in the use of water as pressure medium test pressure is completed or after office hours before blocking test crimping export according to the operation rules of Chapter 4 and 5 is shown to operate. Start the pneumatic pump a water tank used in emulsified oil or hydraulic oil circulation operation to flush the water free to make water in the machine to stay too long and produce rust.

5、试压结束时将空气调压阀的手轮逆时针方向旋转至阀内调压弹簧处于自由状态以延长使用寿命。    。

the end of the air pressure regulating valve handwheel counter clockwise to the valve in pressure regulating spring is in a free state to extend the service life.

6、油雾器内必须有润滑油以润滑气动泵。油量调节为每分钟15-20滴即可油杯内加油必须在无气压时进行。

Lubricating oil lubrication to pneumatic pump, oil mist device must be 6. The oil amount adjustment per minute 15-20 drops cup must be carried out when no air refueling.

7、分水滤气器02中的积水随时放掉过滤杯水要经常清洗干净清洗时先用矿物油清洗再用低压空气吹干杯子切忌用丙酮、乙荃、醋酸盐、甲苯等溶液清洗。因这些溶液将损坏杯子。

02 water separating gas filter water at any time to drain off filter cup of water should be regularly cleaned clean when first with mineral oil, then wash with the low-pressure air dry cup avoid with acetone, ethyl, acetate, toluene and cleaning solution. Because these solutions will damage the cup.

8、本机的试压介质必须保持清洁要经常清洗水箱和过滤器滤网因试压介质不清沽将导致该机的阀类密封不严影响使用。

and the pressure medium must be kept clean to regular cleaning tank and filter due to pressure test medium is not clear sell will lead to the valve class Mifengbuyan influence use.

BACK
map
联系我们:
云南省升中试压泵有限公司
电话:
0877-777796
邮箱:
nxiysof@alberthasgarden.com

版权所有:云南省升中试压泵有限公司, All rights reserved

地址:云南省玉溪市  电话:0877-777796  邮箱: nxiysof@alberthasgarden.com